IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v15y2022i3p1031-d738409.html
   My bibliography  Save this article

CO 2 Capture and Crystallization of ATH Using Sodium Aluminate Solution in a Bubble Column Scrubber

Author

Listed:
  • Pao-Chi Chen

    (Department of Chemical and Materials Engineering, Lunghwa University of Science and Technology, Taoyuan 33306, Taiwan)

  • Shiun-Huang Zhuo

    (Department of Chemical and Materials Engineering, Lunghwa University of Science and Technology, Taoyuan 33306, Taiwan)

  • Jyun-Hong Jhuang

    (Department of Chemical and Materials Engineering, Lunghwa University of Science and Technology, Taoyuan 33306, Taiwan)

Abstract

In this work, sodium aluminate alkaline solution was used to capture CO 2 in a continuous bubble column scrubber and aluminum tri-hydrate (ATH) precipitates were produced. As the sodium carbonate could be recycled after the filtrated solution was crystallized by evaporation, a novel CO 2 capture process was developed successfully. There were five experimental operation variables, including solution flow rate (A), concentration of the solution (B), gas flow rate (C), CO 2 gas concentration (D), and liquid temperature (E), with four levels to each variable. The influence of each variable on absorption efficiency (EF), absorption rate (R A ), absorption factor (φ), mass transfer coefficient (K G a), and precipitation rate (R P ) in a steady state was explored in this study. The Taguchi experimental design was adopted, and 16 experiments were performed; as the optimum operating conditions found in Taguchi analysis required further verification, there were a total of 21 experiments in the end. According to S/N analysis, the overall order of importance was D > A = B > C > E, meaning D (CO 2 concentration) was most important and E (liquid temperature) was least important. In addition, the result also showed that the Rp was 1.25–2.0 times higher than the RA. The obtained powder was mainly ATH according to XRD analysis, with the crystal size ranging between 8.14 and 27.97 nm. However, the BET analysis showed its particle size range being 17.6–283.7 nm, indicating agglomeration for primary particles. The SEM analysis showed that there were flower-like, irregular, urchin-like, elongated, and amorphous particles. The solutions from five groups of optimum conditions were used to recycle the sodium carbonate experiments. After evaporation and crystallization of the filtrated solutions, the energy loading was found to be 1.70–2.56 GJ/t-solvent, illustrating the superiorities of low energy consumption. The precipitated powders were verified to be sodium carbonate by FTIR, which is a valuable constituent.

Suggested Citation

  • Pao-Chi Chen & Shiun-Huang Zhuo & Jyun-Hong Jhuang, 2022. "CO 2 Capture and Crystallization of ATH Using Sodium Aluminate Solution in a Bubble Column Scrubber," Energies, MDPI, vol. 15(3), pages 1-21, January.
    • Handle: RePEc:gam:jeners:v:15:y:2022:i:3:p:1031-:d:738409
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/15/3/1031/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/15/3/1031/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Razzak, Shaikh Abdur & Ali, Saad Aldin M. & Hossain, Mohammad Mozahar & deLasa, Hugo, 2017. "Biological CO2 fixation with production of microalgae in wastewater – A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 76(C), pages 379-390.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Hussain, Fida & Shah, Syed Z. & Ahmad, Habib & Abubshait, Samar A. & Abubshait, Haya A. & Laref, A. & Manikandan, A. & Kusuma, Heri S. & Iqbal, Munawar, 2021. "Microalgae an ecofriendly and sustainable wastewater treatment option: Biomass application in biofuel and bio-fertilizer production. A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 137(C).
    2. Wu, Lan & Wei, Wei & Song, Lan & Woźniak-Karczewska, Marta & Chrzanowski, Łukasz & Ni, Bing-Jie, 2021. "Upgrading biogas produced in anaerobic digestion: Biological removal and bioconversion of CO2 in biogas," Renewable and Sustainable Energy Reviews, Elsevier, vol. 150(C).
    3. Adnan, Muflih A. & Hossain, Mohammad M., 2018. "Gasification of various biomasses including microalgae using CO2 – A thermodynamic study," Renewable Energy, Elsevier, vol. 119(C), pages 598-607.
    4. Qin, Xiang & Wang, Dingbiao & Jin, Zunlong & Wang, Junlei & Zhang, Guojie & Li, Hang, 2021. "A comprehensive investigation on the effect of internal heat exchanger based on a novel evaluation method in the transcritical CO2 heat pump system," Renewable Energy, Elsevier, vol. 178(C), pages 574-586.
    5. Chen, Chunxiang & Huang, Yuting & Qin, Songheng & Huang, Dengchang & Bu, Xiaoyan & Huang, Haozhong, 2020. "Slagging tendency estimation of aquatic microalgae and comparison with terrestrial biomass and waste," Energy, Elsevier, vol. 194(C).
    6. Marwa G. Saad & Noura S. Dosoky & Mohamed S. Zoromba & Hesham M. Shafik, 2019. "Algal Biofuels: Current Status and Key Challenges," Energies, MDPI, vol. 12(10), pages 1-22, May.
    7. Vindel, José M. & Trincado, Estrella, 2021. "Viability assessment of algal wastewater treatment projects under outdoor conditions based on algal productivity and nutrient removal rate," Renewable and Sustainable Energy Reviews, Elsevier, vol. 150(C).
    8. Dahai, He & Zhihong, Yin & Lin, Qin & Yuhong, Li & Lei, Tian & Jiang, Li & Liandong, Zhu, 2024. "The application of magical microalgae in carbon sequestration and emission reduction: Removal mechanisms and potential analysis," Renewable and Sustainable Energy Reviews, Elsevier, vol. 197(C).
    9. Hossain, S. M. Zakir & Sultana, Nahid & Razzak, Shaikh A. & Hossain, Mohammad M., 2022. "Modeling and multi-objective optimization of microalgae biomass production and CO2 biofixation using hybrid intelligence approaches," Renewable and Sustainable Energy Reviews, Elsevier, vol. 157(C).
    10. Yang, Qiulian & Li, Haitao & Wang, Dong & Zhang, Xiaochun & Guo, Xiangqian & Pu, Shaochen & Guo, Ruixin & Chen, Jianqiu, 2020. "Utilization of chemical wastewater for CO2 emission reduction: Purified terephthalic acid (PTA) wastewater-mediated culture of microalgae for CO2 bio-capture," Applied Energy, Elsevier, vol. 276(C).
    11. Li, Ming & Zhou, Minghua & Tian, Xiaoyu & Tan, Chaolin & Gu, Tingyue, 2021. "Enhanced bioenergy recovery and nutrient removal from swine wastewater using an airlift-type photosynthetic microbial fuel cell," Energy, Elsevier, vol. 226(C).
    12. Sultana, N. & Hossain, S.M. Zakir & Albalooshi, H.A. & Chrouf, S.M.B. & AlNajar, I.A. & Alhindi, K.R. & AlMofeez, K.A. & Razzak, S.A. & Hossain, M.M., 2021. "Soft computing modeling and multiresponse optimization for production of microalgal biomass and lipid as bioenergy feedstock," Renewable Energy, Elsevier, vol. 178(C), pages 1020-1033.
    13. Wang, Honglin & Liu, Yanrong & Laaksonen, Aatto & Krook-Riekkola, Anna & Yang, Zhuhong & Lu, Xiaohua & Ji, Xiaoyan, 2020. "Carbon recycling – An immense resource and key to a smart climate engineering: A survey of technologies, cost and impurity impact," Renewable and Sustainable Energy Reviews, Elsevier, vol. 131(C).
    14. Song, Chunfeng & Liu, Qingling & Deng, Shuai & Li, Hailong & Kitamura, Yutaka, 2019. "Cryogenic-based CO2 capture technologies: State-of-the-art developments and current challenges," Renewable and Sustainable Energy Reviews, Elsevier, vol. 101(C), pages 265-278.
    15. Lim, Yi An & Chong, Meng Nan & Foo, Su Chern & Ilankoon, I.M.S.K., 2021. "Analysis of direct and indirect quantification methods of CO2 fixation via microalgae cultivation in photobioreactors: A critical review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 137(C).
    16. Fózer, Dániel & Volanti, Mirco & Passarini, Fabrizio & Varbanov, Petar Sabev & Klemeš, Jiří Jaromír & Mizsey, Péter, 2020. "Bioenergy with carbon emissions capture and utilisation towards GHG neutrality: Power-to-Gas storage via hydrothermal gasification," Applied Energy, Elsevier, vol. 280(C).
    17. Ferreira, G.F. & Ríos Pinto, L.F. & Maciel Filho, R. & Fregolente, L.V., 2019. "A review on lipid production from microalgae: Association between cultivation using waste streams and fatty acid profiles," Renewable and Sustainable Energy Reviews, Elsevier, vol. 109(C), pages 448-466.
    18. Wu, Wenbo & Tan, Ling & Chang, Haixing & Zhang, Chaofan & Tan, Xuefei & Liao, Qiang & Zhong, Nianbing & Zhang, Xianming & Zhang, Yuanbo & Ho, Shih-Hsin, 2023. "Advancements on process regulation for microalgae-based carbon neutrality and biodiesel production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 171(C).
    19. Aziz, Md Maniruzzaman A. & Kassim, Khairul Anuar & Shokravi, Zahra & Jakarni, Fauzan Mohd & Liu, Hong Yuan & Zaini, Nabilah & Tan, Lian See & Islam, A.B.M. Saiful & Shokravi, Hoofar, 2020. "Two-stage cultivation strategy for simultaneous increases in growth rate and lipid content of microalgae: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 119(C).
    20. Wang, Bin & Wang, Shuang-Fei & Lam, Su Shiung & Sonne, Christian & Yuan, Tong-Qi & Song, Guo-Yong & Sun, Run-Cang, 2020. "A review on production of lignin-based flocculants: Sustainable feedstock and low carbon footprint applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 134(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:15:y:2022:i:3:p:1031-:d:738409. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.