IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v297y2024ics036054422401017x.html
   My bibliography  Save this article

Assessment of booster refrigeration system with eco-friendly working fluid CO2/halogenated alkene (HA) mixture for supermarket application around the world: Energy conservation, cost saving, and emissions reduction potential

Author

Listed:
  • Dai, Baomin
  • Wu, Tianhao
  • Liu, Shengchun
  • Zhang, Peng
  • Zhang, Jianing
  • Fu, Rao
  • Wang, Dabiao

Abstract

For the scope of commercial supermarkets, the demand for energy efficiency improvement and environmentally-friendly working fluid of the refrigeration system is necessary. In this study, supermarket booster refrigeration system by using eco-friendly working fluid CO2/halogenated alkene (HA) mixture is proposed, and the mixture used in systems with two evaporation temperatures and operating modes affected by ambient temperature are studied. The energy efficiency, economic performance and emission reduction potential of the whole life cycle are conducted to compare with the pure CO2 booster refrigeration system. Furthermore, the influence of climate condition is discussed when used in 40 typical cities around the world. The results show the coefficient of performance (COP) of booster refrigeration system can be significantly improved by using CO2/HA mixtures. As the ambient temperature is 33 °C, the CO2/R1234yf (93/7) operates with the maximum COP of 1.367, which is 11.59 % higher than that of pure CO2. Using CO2/HA mixtures in the booster refrigeration system can significantly improve the exergy efficiency of system. Moreover, the system using CO2/HA mixtures has higher annual performance factor and lower life cycle cost (LCC) than pure CO2. LCC of the system using CO2/R1234yf (94/6) is the lowest, and the reduction rate is 3.06–5.59 %. Meanwhile, the life cycle carbon emissions of systems in different climatic regions using CO2/R1234yf can be reduced by 2.39–5.21 %. The booster refrigeration system adopting CO2/HA mixtures is a promising alternative solution for commercial supermarket refrigeration and energy-saving.

Suggested Citation

  • Dai, Baomin & Wu, Tianhao & Liu, Shengchun & Zhang, Peng & Zhang, Jianing & Fu, Rao & Wang, Dabiao, 2024. "Assessment of booster refrigeration system with eco-friendly working fluid CO2/halogenated alkene (HA) mixture for supermarket application around the world: Energy conservation, cost saving, and emiss," Energy, Elsevier, vol. 297(C).
    • Handle: RePEc:eee:energy:v:297:y:2024:i:c:s036054422401017x
    DOI: 10.1016/j.energy.2024.131244
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S036054422401017X
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2024.131244?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Michał Sobieraj, 2020. "Experimental Investigation of the Effect of a Recuperative Heat Exchanger and Throttles Opening on a CO 2 /Isobutane Autocascade Refrigeration System," Energies, MDPI, vol. 13(20), pages 1-15, October.
    2. Zhang, Qunli & Zhang, Lin & Nie, Jinzhe & Li, Yinlong, 2017. "Techno-economic analysis of air source heat pump applied for space heating in northern China," Applied Energy, Elsevier, vol. 207(C), pages 533-542.
    3. Kravanja, Gregor & Zajc, Gašper & Knez, Željko & Škerget, Mojca & Marčič, Simon & Knez, Maša H., 2018. "Heat transfer performance of CO2, ethane and their azeotropic mixture under supercritical conditions," Energy, Elsevier, vol. 152(C), pages 190-201.
    4. Tsamos, K.M. & Ge, Y.T. & Santosa, I.D.M.C. & Tassou, S.A., 2017. "Experimental investigation of gas cooler/condenser designs and effects on a CO2 booster system," Applied Energy, Elsevier, vol. 186(P3), pages 470-479.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Guozhong Zheng & Wentao Bu, 2018. "Review of Heating Methods for Rural Houses in China," Energies, MDPI, vol. 11(12), pages 1-18, December.
    2. Yuan, Zhipeng & Liu, Qi & Luo, Baojun & Li, Zhenming & Fu, Jianqin & Chen, Jingwei, 2018. "Thermodynamic analysis of different oil flooded compression enhanced vapor injection cycles," Energy, Elsevier, vol. 154(C), pages 553-560.
    3. Zhou, Chaohui & Ni, Long & Li, Jun & Lin, Zeri & Wang, Jun & Fu, Xuhui & Yao, Yang, 2019. "Air-source heat pump heating system with a new temperature and hydraulic-balance control strategy: A field experiment in a teaching building," Renewable Energy, Elsevier, vol. 141(C), pages 148-161.
    4. Behzadi, Amirmohammad & Holmberg, Sture & Duwig, Christophe & Haghighat, Fariborz & Ooka, Ryozo & Sadrizadeh, Sasan, 2022. "Smart design and control of thermal energy storage in low-temperature heating and high-temperature cooling systems: A comprehensive review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 166(C).
    5. Du, Mingxi & Wang, Xiaoge & Peng, Changhui & Shan, Yuli & Chen, Huai & Wang, Meng & Zhu, Qiuan, 2018. "Quantification and scenario analysis of CO2 emissions from the central heating supply system in China from 2006 to 2025," Applied Energy, Elsevier, vol. 225(C), pages 869-875.
    6. Dong, Yixiu & Yan, Hongzhi & Wang, Ruzhu, 2024. "Significant thermal upgrade via cascade high temperature heat pump with low GWP working fluids," Renewable and Sustainable Energy Reviews, Elsevier, vol. 190(PA).
    7. Ma, Sining & Guo, Siyue & Zheng, Dingqian & Chang, Shiyan & Zhang, Xiliang, 2021. "Roadmap towards clean and low carbon heating to 2035: A provincial analysis in northern China," Energy, Elsevier, vol. 225(C).
    8. Liu, Ziyang & He, Mingfei & Tang, Xiaoping & Yuan, Guofeng & Yang, Bin & Yu, Xiaohui & Wang, Zhifeng, 2024. "Capacity optimisation and multi-dimensional analysis of air-source heat pump heating system: A case study," Energy, Elsevier, vol. 294(C).
    9. Li, Gang & Du, Yuqing, 2018. "Performance investigation and economic benefits of new control strategies for heat pump-gas fired water heater hybrid system," Applied Energy, Elsevier, vol. 232(C), pages 101-118.
    10. Xuebin Ma & Junfeng Li & Yucheng Ren & Reaihan E & Qiugang Wang & Jie Li & Sihui Huang & Mingguo Ma, 2022. "Performance and Economic Analysis of the Multi-Energy Complementary Heating System under Different Control Strategies in Cold Regions," Energies, MDPI, vol. 15(21), pages 1-17, November.
    11. Felten, Björn & Weber, Christoph, 2018. "The value(s) of flexible heat pumps – Assessment of technical and economic conditions," Applied Energy, Elsevier, vol. 228(C), pages 1292-1319.
    12. Xiao, Biao & Chang, Huawei & He, Lin & Zhao, Shunan & Shu, Shuiming, 2020. "Annual performance analysis of an air source heat pump water heater using a new eco-friendly refrigerant mixture as an alternative to R134a," Renewable Energy, Elsevier, vol. 147(P1), pages 2013-2023.
    13. Li, Sihui & Gong, Guangcai & Peng, Jinqing, 2019. "Dynamic coupling method between air-source heat pumps and buildings in China’s hot-summer/cold-winter zone," Applied Energy, Elsevier, vol. 254(C).
    14. Zhenying Zhang & Jiaqi Wang & Meiyuan Yang & Kai Gong & Mei Yang, 2022. "Environmental and Economic Analysis of Heating Solutions for Rural Residences in China," Sustainability, MDPI, vol. 14(9), pages 1-15, April.
    15. Qinli Deng & Liangxin Xu & Tingfang Zhao & Xuexin Hong & Xiaofang Shan & Zhigang Ren, 2022. "Cooperative Optimization of A Refrigeration System with A Water-Cooled Chiller and Air-Cooled Heat Pump by Coupling BPNN and PSO," Energies, MDPI, vol. 15(19), pages 1-19, September.
    16. Xu, Wei & Liu, Changping & Li, Angui & Li, Ji & Qiao, Biao, 2020. "Feasibility and performance study on hybrid air source heat pump system for ultra-low energy building in severe cold region of China," Renewable Energy, Elsevier, vol. 146(C), pages 2124-2133.
    17. Wang, Jinda & Zhou, Zhigang & Zhao, Jianing & Zheng, Jinfu & Guan, Zhiqiang, 2019. "Optimizing for clean-heating improvements in a district energy system with high penetration of wind power," Energy, Elsevier, vol. 175(C), pages 1085-1099.
    18. Wang, Naigen & Ye, Qing & Chen, Lijuan & Zhang, Haoxiang & Zhong, Jing, 2021. "Improving the economy and energy efficiency of separating water/acetonitrile/isopropanol mixture via triple-column pressure-swing distillation with heat-pump technology," Energy, Elsevier, vol. 215(PA).
    19. Zhang, Xi & Strbac, Goran & Teng, Fei & Djapic, Predrag, 2018. "Economic assessment of alternative heat decarbonisation strategies through coordinated operation with electricity system – UK case study," Applied Energy, Elsevier, vol. 222(C), pages 79-91.
    20. Zhongbao Liu & Fengfei Lou & Xin Qi & Yiyao Shen, 2020. "Enhancing Heating Performance of Low-Temperature Air Source Heat Pumps Using Compressor Casing Thermal Storage," Energies, MDPI, vol. 13(12), pages 1-18, June.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:297:y:2024:i:c:s036054422401017x. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.