IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v173y2019icp1208-1220.html
   My bibliography  Save this article

Stabilizing operation of a solar aided power generation (SAPG) plant by adjusting the burners’ tilt and attemperation flows in the boiler

Author

Listed:
  • Huang, Chang
  • Hou, Hongjuan
  • Hu, Eric
  • Yu, Gang
  • Peng, Hao
  • Zhao, Jin
  • Yang, Yongping

Abstract

Solar Aided Power Generation (SAPG) technology has been proved to be one of the most efficient ways to integrate solar energy into a coal-fired power plant. However, previous studies on SAPG systems have mainly focused on their design and design optimization. There are few studies on their operation. In an SAPG plant, solar heat is used to replace the extracted steam to preheat feedwater. However, the introduction of solar energy inevitably affects the steam flow rate through the boiler, especially when the SAPG plant is in fuel-saving operation mode, thus affecting the boiler's operation. Namely, the steam parameters at the boiler outlets would change with various solar inputs if no control mechanism were applied. A mechanism for adjusting the burners' tilt and attemperation flows in the boiler is therefore proposed in this study, in order to stabilize the temperature of the steam at the outlet of the boiler. To simulate the effectiveness of the mechanism, a transient model of the SAPG plant, including a series of modules for key components in the plant, has been developed in this study. The simulation results in a case study of a 300 MWe SAPG plant, showing the proportion of heat that was absorbed in the boiler was redistributed due to the solar input, without adjusting the burners' tilt and attemperation flows, resulting in temperature drops of superheated/reheated steam when in a fuel-saving mode. However, the simulation in the case study also shows that by swinging the burner tilt angle up to 22.7° and adjusting the attemperation flows in the super-heaters and re-heaters in the boiler, the superheated/reheated steam temperature can be restored from 523 °C and 510 °C respectively back to 543.0 °C, the desired temperature.

Suggested Citation

  • Huang, Chang & Hou, Hongjuan & Hu, Eric & Yu, Gang & Peng, Hao & Zhao, Jin & Yang, Yongping, 2019. "Stabilizing operation of a solar aided power generation (SAPG) plant by adjusting the burners’ tilt and attemperation flows in the boiler," Energy, Elsevier, vol. 173(C), pages 1208-1220.
    • Handle: RePEc:eee:energy:v:173:y:2019:i:c:p:1208-1220
    DOI: 10.1016/j.energy.2019.02.139
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S036054421930338X
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2019.02.139?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Huang, Chang & Hou, Hongjuan & Hu, Eric & Liang, Mingyu & Yang, Yongping, 2017. "Impact of power station capacities and sizes of solar field on the performance of solar aided power generation," Energy, Elsevier, vol. 139(C), pages 667-679.
    2. Hou, Hongjuan & Xu, Zhang & Yang, Yongping, 2016. "An evaluation method of solar contribution in a solar aided power generation (SAPG) system based on exergy analysis," Applied Energy, Elsevier, vol. 182(C), pages 1-8.
    3. Wu, Junjie & Hou, Hongjuan & Yang, Yongping & Hu, Eric, 2015. "Annual performance of a solar aided coal-fired power generation system (SACPG) with various solar field areas and thermal energy storage capacity," Applied Energy, Elsevier, vol. 157(C), pages 123-133.
    4. Hong-juan, Hou & Zhen-yue, Yu & Yong-ping, Yang & Si, Chen & Na, Luo & Junjie, Wu, 2013. "Performance evaluation of solar aided feedwater heating of coal-fired power generation (SAFHCPG) system under different operating conditions," Applied Energy, Elsevier, vol. 112(C), pages 710-718.
    5. Bakos, G.C. & Parsa, D., 2013. "Technoeconomic assessment of an integrated solar combined cycle power plant in Greece using line-focus parabolic trough collectors," Renewable Energy, Elsevier, vol. 60(C), pages 598-603.
    6. Dersch, Jürgen & Geyer, Michael & Herrmann, Ulf & Jones, Scott A. & Kelly, Bruce & Kistner, Rainer & Ortmanns, Winfried & Pitz-Paal, Robert & Price, Henry, 2004. "Trough integration into power plants—a study on the performance and economy of integrated solar combined cycle systems," Energy, Elsevier, vol. 29(5), pages 947-959.
    7. Hou, Hongjuan & Wu, Junjie & Yang, Yongping & Hu, Eric & Chen, Si, 2015. "Performance of a solar aided power plant in fuel saving mode," Applied Energy, Elsevier, vol. 160(C), pages 873-881.
    8. Erdinc, O. & Uzunoglu, M., 2012. "Optimum design of hybrid renewable energy systems: Overview of different approaches," Renewable and Sustainable Energy Reviews, Elsevier, vol. 16(3), pages 1412-1425.
    9. Peng, Shuo & Hong, Hui & Wang, Yanjuan & Wang, Zhaoguo & Jin, Hongguang, 2014. "Off-design thermodynamic performances on typical days of a 330MW solar aided coal-fired power plant in China," Applied Energy, Elsevier, vol. 130(C), pages 500-509.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Huang, Chang & Madonski, Rafal & Zhang, Qi & Yan, Yixian & Zhang, Nan & Yang, Yongping, 2022. "On the use of thermal energy storage in solar-aided power generation systems," Applied Energy, Elsevier, vol. 310(C).
    2. Yan, Hui & Chong, Daotong & Wang, Zhu & Liu, Ming & Zhao, Yongliang & Yan, Junjie, 2022. "Dynamic performance enhancement of solar-aided coal-fired power plant by control strategy optimization with solar/coal-to-power conversion characteristics," Energy, Elsevier, vol. 244(PA).
    3. Huang, Chang & Hou, Hongjuan & Hu, Eric & Yu, Gang & Peng, Hao & Yang, Yongping & Wang, Lu & Zhao, Jin, 2019. "Performance maximization of a solar aided power generation (SAPG) plant with a direct air-cooled condenser in power-boosting mode," Energy, Elsevier, vol. 175(C), pages 891-899.
    4. Heng Zhang & Na Wang & Kai Liang & Yang Liu & Haiping Chen, 2021. "Research on the Performance of Solar Aided Power Generation System Based on Annular Fresnel Solar Concentrator," Energies, MDPI, vol. 14(6), pages 1-23, March.
    5. Yan, Hui & Liu, Ming & Wang, Zhu & Zhang, Kezhen & Chong, Daotong & Yan, Junjie, 2023. "Flexibility enhancement of solar-aided coal-fired power plant under different direct normal irradiance conditions," Energy, Elsevier, vol. 262(PA).
    6. Huang, Chang & Hou, Hongjuan & Yu, Gang & Zhang, Le & Hu, Eric, 2020. "Energy solutions for producing shale oil: Characteristics of energy demand and economic analysis of energy supply options," Energy, Elsevier, vol. 192(C).
    7. Huang, Chang & Hou, Hongjuan & Hu, Eric & Yu, Gang & Chen, Si & Yang, Yongping, 2020. "Measures to reduce solar energy dumped in a solar aided power generation plant," Applied Energy, Elsevier, vol. 258(C).
    8. Liu, Hongtao & Zhai, Rongrong & Patchigolla, Kumar & Turner, Peter & Yang, Yongping, 2020. "Performance analysis of a novel combined solar trough and tower aided coal-fired power generation system," Energy, Elsevier, vol. 201(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Huang, Chang & Hou, Hongjuan & Hu, Eric & Yu, Gang & Peng, Hao & Yang, Yongping & Wang, Lu & Zhao, Jin, 2019. "Performance maximization of a solar aided power generation (SAPG) plant with a direct air-cooled condenser in power-boosting mode," Energy, Elsevier, vol. 175(C), pages 891-899.
    2. Hou, Hongjuan & Xu, Zhang & Yang, Yongping, 2016. "An evaluation method of solar contribution in a solar aided power generation (SAPG) system based on exergy analysis," Applied Energy, Elsevier, vol. 182(C), pages 1-8.
    3. Li, Chao & Zhai, Rongrong & Yang, Yongping & Patchigolla, Kumar & Oakey, John E. & Turner, Peter, 2019. "Annual performance analysis and optimization of a solar tower aided coal-fired power plant," Applied Energy, Elsevier, vol. 237(C), pages 440-456.
    4. Zhang, Nan & Hou, Hongjuan & Yu, Gang & Hu, Eric & Duan, Liqiang & Zhao, Jin, 2019. "Simulated performance analysis of a solar aided power generation plant in fuel saving operation mode," Energy, Elsevier, vol. 166(C), pages 918-928.
    5. Huang, Chang & Hou, Hongjuan & Hu, Eric & Yu, Gang & Chen, Si & Yang, Yongping, 2020. "Measures to reduce solar energy dumped in a solar aided power generation plant," Applied Energy, Elsevier, vol. 258(C).
    6. Zhang, Nan & Yu, Gang & Huang, Chang & Duan, Liqiang & Hou, Hongjuan & Hu, Eric & Ding, Zeyu & Wang, Jianhua, 2020. "Full-day dynamic characteristics analysis of a solar aided coal-fired power plant in fuel saving mode," Energy, Elsevier, vol. 208(C).
    7. Li, Chao & Yang, Zhiping & Zhai, Rongrong & Yang, Yongping & Patchigolla, Kumar & Oakey, John E., 2018. "Off-design thermodynamic performances of a solar tower aided coal-fired power plant for different solar multiples with thermal energy storage," Energy, Elsevier, vol. 163(C), pages 956-968.
    8. Zhang, Maolong & Xu, Chao & Du, Xiaoze & Amjad, Muhammad & Wen, Dongsheng, 2017. "Off-design performance of concentrated solar heat and coal double-source boiler power generation with thermocline energy storage," Applied Energy, Elsevier, vol. 189(C), pages 697-710.
    9. Jun Zhao & Kun Yang, 2020. "Analysis of CO 2 Abatement Cost of Solar Energy Integration in a Solar-Aided Coal-Fired Power Generation System in China," Sustainability, MDPI, vol. 12(16), pages 1-17, August.
    10. Wu, Junjie & Han, Yu & Hou, Hongjuan & Sun, Yingying, 2020. "Optimization of solar field layout and flow velocity in a solar-aided power generation system," Energy, Elsevier, vol. 208(C).
    11. Shagdar, Enkhbayar & Lougou, Bachirou Guene & Shuai, Yong & Anees, Junaid & Damdinsuren, Chimedsuren & Tan, Heping, 2020. "Performance analysis and techno-economic evaluation of 300 MW solar-assisted power generation system in the whole operation conditions," Applied Energy, Elsevier, vol. 264(C).
    12. Wu, Junjie & Hou, Hongjuan & Yang, Yongping & Hu, Eric, 2015. "Annual performance of a solar aided coal-fired power generation system (SACPG) with various solar field areas and thermal energy storage capacity," Applied Energy, Elsevier, vol. 157(C), pages 123-133.
    13. Bame, Aaron T. & Furner, Joseph & Hoag, Ian & Mohammadi, Kasra & Powell, Kody & Iverson, Brian D., 2022. "Optimization of solar-coal hybridization for low solar augmentation," Applied Energy, Elsevier, vol. 319(C).
    14. Jun Zhao & Kun Yang, 2020. "Allocating Output Electricity in a Solar-Aided Coal-Fired Power Generation System and Assessing Its CO 2 Emission Reductions in China," Sustainability, MDPI, vol. 12(2), pages 1-15, January.
    15. Huang, Chang & Madonski, Rafal & Zhang, Qi & Yan, Yixian & Zhang, Nan & Yang, Yongping, 2022. "On the use of thermal energy storage in solar-aided power generation systems," Applied Energy, Elsevier, vol. 310(C).
    16. Zhai, Rongrong & Zhao, Miaomiao & Tan, Kaiyu & Yang, Yongping, 2015. "Optimizing operation of a solar-aided coal-fired power system based on the solar contribution evaluation method," Applied Energy, Elsevier, vol. 146(C), pages 328-334.
    17. Liu, Hongtao & Zhai, Rongrong & Patchigolla, Kumar & Turner, Peter & Yang, Yongping, 2020. "Performance analysis of a novel combined solar trough and tower aided coal-fired power generation system," Energy, Elsevier, vol. 201(C).
    18. Wu, Junjie & Han, Yu, 2023. "Integration strategy optimization of solar-aided combined heat and power (CHP) system," Energy, Elsevier, vol. 263(PC).
    19. Shagdar, Enkhbayar & Shuai, Yong & Lougou, Bachirou Guene & Mustafa, Azeem & Choidorj, Dashpuntsag & Tan, Heping, 2022. "New integration mechanism of solar energy into 300 MW coal-fired power plant: Performance and techno-economic analysis," Energy, Elsevier, vol. 238(PC).
    20. Wang, Ruilin & Sun, Jie & Hong, Hui & Jin, Hongguang, 2018. "Comprehensive evaluation for different modes of solar-aided coal-fired power generation system under common framework regarding both coal-savability and efficiency-promotability," Energy, Elsevier, vol. 143(C), pages 151-167.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:173:y:2019:i:c:p:1208-1220. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.